Archive for category Bosch Spares & Repairs News
Bosch Dishwasher Not Cleaning
Posted by admin in Bosch Spares & Repairs News, Dishwasher Spares & Repair News, Engineers Service Call Repair Diary on May 18th, 2010
Customer Service Call Request
Bosch dishwasher not cleaning properly.
Engineers repair comments.
On my arrival i put the bosch dishwasher no a quick wash cycle, the machine filled normally then the motor started to run, the Bosch dishwasher detergent dispenser opened and the Dishwasher started to heat. I then opened the door & set both top and bottom spray arms facing the front door, shut the door and ran the machine for 30 seconds, opened the door again to see if the spray arms had moved from the position i had put them in, the bottom arm had moved but the top spray arm way still in the same position. I replaced the top spray arm and carried out the same test. This time the Boschdishwasher spray arms both changed direction. We would add that for effient cleaning both spray arms need to be in good condition, being worn on the center fitting and splits along the sides can give very poor washing results
Bosch Washing Machine Brushes
Posted by admin in Bosch Spares & Repairs News, Engineers Service Call Repair Diary, Washing Spares and Repairs News on June 5th, 2009
Customer Service Call Request
Bosch washing machine drum not turning
Engineers repair comments.
On inspection of the Bosch WFL2260 washing machine i found that the drum wasn’t turning. I could hear the relay on the control module pcb clicking on & off which meant that the electronic control module was ok and sending the electrical power down to the motor so my next port of call was checking the Bosch washing machine brushes to do this you remove the back panel and the motor from the drum fixings held on by two 10mm screws then release the wire terminal block from the motor, remove the motor from underneath the bosch washing machine then turn the motor on end to gain access to the Bosch carbon brushes, unclip the wire to the carbon brush and release the brush sprung loaded clip from brush housing, pull the carbon brush out repeat this on the other sides of the motor. You must then clean the motor armiture with a very fine piece of wet & dry sand paper untill it is a shining, this to remove the old carbon from the motor armiture. Fit the new brushes into the carbon brush housing and then fit the rest of the Bosch washing machine back together.
Bosch washing machine not starting
Posted by admin in Bosch Spares & Repairs News, Engineers Service Call Repair Diary, Washing Spares and Repairs News on June 4th, 2009
Customer Service Call Request
Bosch washing machine not starting don’t know if it needs any spare parts
Engineers repair comments.
On inspection of the customers WFF2000 Bosch washing machine i found that the on-off button wasn’t staying in, i removed the Bosch washing machine top to gain access to the on off switch, i removed the switch by lifting the tab ob top of the switch then lifting the on off switch upward, continued to removing the wiring cables and the rope cable that goes to the door lock then fitted the new on off switch in reverse to the way, tested the Bosch washing machine all tested ok.
Bosch Dishwasher Not Draining
Posted by admin in Bosch Spares & Repairs News, Engineers Service Call Repair Diary on May 20th, 2009
Customer Service Call Request
Bosch Dishwasher not draining.
Engineers repair comments.
On my arrival i tested to see if any Bosch dishwasher spare parts were required and what the fault was. At the beginning of every cycle ( on a Bosch dishwasher ) the dishwasher carried out a drain cycle for about 2 minutes, After this period the dishwasher will start to fill with water. But when i first put the dishwasher on test the Bosch drain pump started and some of the water drained away but not all of it, i opened the door to see if the micro drain filter 427903 was blocked and it was full of old rotten food, i emptied and cleaned the filter then tested the machine and it drained away in record time.
Bosch Dishwasher Spares & Spare Parts
Posted by admin in Bosch Spares & Repairs News, Engineers Service Call Repair Diary on May 19th, 2009
Customer Service Call Request
Bosch Dishwasher not heating and cycle sticking.
Engineers repair comments.
I called at the customers house to inspect the SGV43A03 Bosch dishwasher to see if any Bosch dishwasher spare parts were required. I found that when the machine was filling with water it would fill for 5 -10 seconds then stop for 5 - 10 seconds then fill again for 5- 10 seconds and so on.i removed the left hand side panel to find that the water filling chamber
and sump hose were blocked with food particals and general gunk, I changed the water chamber and cleaned the sump hose. I tested the machine to see if any Dishwasher spare parts were needed, everything tested ok so i refitted the side panel. Another completed repair.
Bosch Washing Machine Spare Parts
Posted by admin in Bosch Spares & Repairs News on May 14th, 2009
Bosch Washing Machine Spare Parts.
Bosch washing machines are a very popular choice of washing machine with today’s customer, they are a very reliable product but some Bosch washing machine spare parts are possible to fail. The most common part to be replaced are motor carbon brushes, Door gasket rubber seals , drain pumps and heating elements but in general only the wear and tear parts are replaced.
Bosch Washing Machine Filter
Posted by admin in Bosch Spares & Repairs News, Engineers Service Call Repair Diary, Washing Spares and Repairs News on May 12th, 2009
Customer Service Call Request
My Bosch machine WFF2001 is not draining the water out.
Engineers repair comments.
On inspection of the washing machine i found water left in the machine, I then had it find out if it needed any Bosch Washing machine spare parts. First i put the machine on a drain cycle, the drain pump made a buzzing noise but didn’t run. I then removed the drain filter and found a hair clip stopping the pump impellor from turning, I removed the hair clip refitted the filter and tested the bosch washing machine. I then carried out a function test and all was working correctly.
Bosch Washing Machine Door Seal
Posted by admin in Bosch Spares & Repairs News, Engineers Service Call Repair Diary, Washing Spares and Repairs News on April 23rd, 2009
Customer Servic Call Request
My Bosch washing machine is leaking.
Engineers repair comments.
On inspection of the customers bosch washing machine i found a slight tear in the rubber door seal. I replaced the Bosch washing machine door seal Part no 354135 by removing the sprung loaded clip that holds the door seal to the front of the washing machine cabinet, then i removed the front cabinet and disconnecting the door lock from the front cabinet, I removed then removed the spring clip that holds the rubber door seal to the outer drum. I then replaced the rubber door boot with a new Bosch washing machine spare part ( we mostly use genuine Bosch washing machine spares ), replaced the spring clips, door lock and front cabinet then tested no leaks were found.